Resurrecting Sandy, a 1952 Plymouth Cranbrook that drowned in Hurricane Sandy, has proven to be the Two Horsemen of the Carpocalypse’s biggest challenge yet. That is saying a lot for a team that has brought a $150 1989 Dodge Shadow, a $200 1973 Plymouth Valiant, and a $300 1969 Dodge Dart Custom back to life from under tarps and woodpiles and abandoned behind barns for glorious 3,000-mile journeys to raise over $12,000 for charity over the course of five rallies in five years.
Sandy was on her way to the crusher when a friend of Team Two Horsemen of the Carpocalypse (Jim Thwaite of Asphault Adventures) rescued her, knowing Crash and Burn would want to get this unusual classic back on the road and competing in rallies to raise money for charity. Jim not only rescued the car, but hosted it in his garage and did the lion’s share of the work to get the car running and ready for transport to Crash’s pad in Atlanta.
After spending days submerged in water above the dashboard during Hurricane Sandy and a year rusting after the floodwaters receded, the car was a total loss. Water had seeped into the engine and transmission leaving them unsalvageable – discovered only after weeks of effort to restore them believing they had been pickled before the storm. The drivetrain ultimately was replaced with “leftovers” from the hot rod conversion of a 1949 Dodge sold to the team for the scrap value of the metal. The gas tank, differential, and radiator took in some water as well, but ultimately would be saved after the investment of hours of effort to recondition them. The entire ignition system was destroyed by corrosion and rust and had to be rebuilt from scratch – a custom-wired 12v ignition circuit based on 1970s Ford F-100 parts. A one-wire GM alternator was installed using a bracket custom-made by Jim to provide charging.
Two years to the day since Hurricane Sandy ravaged New Jersey, the Cranbrook has been transported from Jim’s garage in New Jersey to Crash’s garage in Atlanta, and the second phase of Sandy’s restoration to the road will begin over the Thanksgiving holiday:
- The rest of the electrical system, from the switches to the bulb bases, was a total loss as well. A decision has been made to rewire the car using a 12v hot-rod wiring harness and fusebox. This conversion isn’t yet complete and some challenges remain with finding replacements for the 6v blower motor, horn, and windshield wiper motor that also were destroyed by the storm waters. The entire dash cluster was submerged and was corroded beyond repair.
- A replacement dash cluster has been obtained but hasn’t yet been installed, and several of the gauges may not be compatible due to minor differences between sensors and outputs on the 1949 versus 1952 engine and transmission. The team is debating whether a digital dashboard using an Android tablet and new wireless sensors may be a future project and a way to extend the life of this classic Plymouth.
- The brakes and wheel bearings were a total loss as well, and everything except the master brake cylinder has been replaced. For safety’s sake, a rebuild or replacement of the master cylinder is in order.
- The 1949 transmission appears to have some 1st gear issues and likely will need to be rebuilt or replaced.
- The differential (a seemingly never-ending Achilles’ Heel for the team’s rally cars) needs to be gone through as it took on water in the flood, and a rebuild or replacement may be necessary.
- The steering and suspension need to be gone through, and some replacement of bushings and bearings likely will be required.
It may take a while but Sandy will drive again. Assuming all goes well, Sandy’s first rally is targeted to be Asphault Adventures’ West Virginia to Key West Rally in May/June 2015.
Please look for updates on Sandy’s restoration on Two Horsemen of the Carpocalypse’s Facebook page and here on the team’s website (www.thotc.com) for updates.
Thanks for reading, and see you on the road!
Two Horsemen of the Carpocalypse 
Leave a Reply